Bruce and I and my Dad replaced the thermostat, timing belt, water pump, and thermostat on the P. All went well, except that VW doesn't know how to do their job very well and got the wrong pulleys. But they did get everything else correct, and for a good price too.
today I replaced the thermostat on my GLI too. What a pain in the ass!!! my back hurts so bad!. Anyways it took me almost 6 hours to complete the job. Now the car feels a lot more powerful, the old thermostat was opening at 80oC so it was overcooled all the time, heater just blew mild hot not hotter as it should and it was burning gas like a v8, It was doing 16-18mpg at most in city driving. I just checked with VCDS and the engine temp is at a solid 93oC constant temp, I took it for a ride for about 10 miles and it did 28mpg so I am pretty confident that the old thermostat just plain sucked. 6 hours well spent!
I've had that occur - it was a bad thermostat. It would stick very slightly open. At idle, or in city driving, it was not noticeable. However, on the highway, the gauge would start to drop and the interior of the vehicle would get colder.
The thermostat I pulled out was probably original, but wasn't stuck. After replacing the timing belt and thermostat, I filled the car back up with coolant and started it up. It did come up to operating temperature quicker
I replaced mine with a low temp thermostat and low temp fan sensor aswell as the infamous blue coolant temp sensor a week ago and everything ran so much cooler and smoother now. My coolant temp sensor failed for weeks and wouldn't run the low speed fan and the water temp was 30-40 degree hotter than usual. Now it's all good with AC blasting in bumper to bumper traffic for 1 hour and it water temp reads 205-215, but my oil are in the 240's.
I'll throw a lower temp thermostat see if I can get her temp to stay low as possible for now
mine is also a problem an my car is 1.5 yrs old. Sometimes the temp gauge acts as if it is -40C outside even if it is a couple degrees above freezing. Often the car will take 4-5minutes to get near base idle when it is cool outside, but when it's really cold, sometimes it takes 30seconds and there is no way it's warmed up. Can also smell coolant anytime I open the hood. Sad.
I had my water pump and thermostat changed in August under warranty. I went for an oil change in Dec and they told me they think the thermostat is leaking. I told them they just replaced it 4 months ago. They went back and cleaned up the area around the thermostat and oil pan and said we need to monitor it to see if it's really leaking again. They were not surprised when I asked if it was possible it could be leaking again. They told me they see the part fail all the time.
never trust an aftermarket thermostat! Especially if it has MOTORAD stamped on it.
Oreillys used to have Motorad thermostats that were 2-5$. Then they started carrying Murray, which are double the price. Guess what's in the box? Motorad. Cheap crap for a premium price.
Write your review
Help others - share your experience with this part.
Voted AGAINST engine oil RAVENOL on the rating page
The power steering pump OEM Volvo got the first review!
The brake pads OEM Infiniti got the first review!
The brake cylinder Raybestos got the first review!
For tires OEM Toyota already 25 reviews.
For tires IRONMAN already 25 reviews.
In the rating best fuel pump already 5 brands participate!
In the rating best antifreeze already 9 brands participate!
In the rating best engine radiator already 9 brands participate!
In the auto rating shock absorbers for Ford Ranger already 20 brands participate!
In the auto rating brake discs for Volkswagen Golf already 10 brands participate!
In the auto rating headlights for Volkswagen Golf already 5 brands participate!
For wiper blades PIAA already 100 reviews.
Voted AGAINST engine oil RED LINE on the rating page
Voted AGAINST engine oil PENNZOIL on the rating page
