I had the impression that those discs wouldn’t warp as easy as one piece discs but it looks as I was wrong. VW tried to machine my warped discs with them mounted on the car at one point but they failed so badly that they did not even want to show me the result. After that they messured the runout on new discs on the bench and found them OK. After the discs were mounted on the hubs they were messured again and that one of them had warped. That was the way they found the bad hub. I was quite surprised when I was told that VW did not have any tolerances for the runout on the hubs or the discs. I took for granted that they had quite strict tolerances both on the hubs and the discs. I don’t know if the eight piston caliper and the setup with opposed pistons makes the whole system more sensitive to warpage or not but that has been suggested. And to get this a bit more connected to the thread subject I can add that I have not found any alternative to VW original 365 mm floating discs at all. I was quite surprised to find them cheaper than the one piece 334 mm discs to my Passat W8 though.
Reviews of spare parts for Volkswagen Phaeton
Could be the hubs. Mine had an axial throw of 0,02-0,03 mm which I thought wouldn’t affect the discs. I filed a complainment to VW regarding warped discs and they blamed the calipers. Told me one of eight pistons was a bit sluggish. With new calipers and two sets of discs later they found what I had meassured before the complainment, a warped hub. The last pair have not warped after the typical 5000 km mark as before. So at least the floating 365 mm discs are very sensitive regarding straight hubs.
I replaced mine two years ago, both rotors and pads front and rear, with VW parts purchased from VWpartsvortex. As I recall, they were not Brembo, probably ATE. I spent a total of $718 on the set, which seemed reasonable considering the rotor size and how long they last. So far, the new ones are performing very well. As an aside, a few years ago I replaced the rotors with Brembos on a Subaru and was disappointed: the front ones warped almost immediately. The bottom line, I'm afraid, is that it is no longer enough to rely on the brand, especially if sourced on the secondary market. At least with "VW" marked parts the reputation of the vehicle manufacturer is on the line, though even that may not be enough to ensure high quality.
I think the ones I just fitted on the front are TRW, they were significantly cheaper than the genuine parts I've previously bought, but the performance is at least as good, with less brake dust. There's a big difference between quality and cheap parts when it comes to brakes, cheaper rotors will be much more likely to warp.
Finished! I got the new fuel pump installed last night (finished right at 10pm) and took it for a short test drive with just a 1/4 tank of gas. It looks like everything is working properly now, no surging, no stalling, and it idles better now than before
Hello, I just had the windshield on my 2006 W12 replaced and it has the IR/A stamp.
Over the last 6 months I have replaced all front suspension control arms with new TRW arms.
Comfort battery charged up. Starter battery didn't take much time to charge. I really like this charger and it seems to be getting great reviews. It has a number of different modes it automatically works in depending on what it senses from the battery and how long you leave it plugged in for. It's really small... it has an AGM mode... it has a high capacity starting mode...
installed new Exide EK950 AGM 95AH to replace same model been there 3years. No change, and also former battery checks to be in nearly new condition still with measured 90AH capacity from fully charged to 10,5v 9hours with 10Amp load.
My low tone horn (the high-mounted one) faild and was recently replaced by the dealer. The high note alone sounds weird!
Write your review
Help others - share your experience with this part.
Voted AGAINST engine oil RAVENOL on the rating page
The brake pads OEM Alfa Romeo got the first review!
The brake caliper OEM BMW got the first review!
The brake pads OEM Infiniti got the first review!
For wiper blades PIAA already 100 reviews.
For battery Energizer already 25 reviews.
In the rating best water pump already 12 brands participate!
In the rating best timing belt already 13 brands participate!
In the rating best head gasket already 3 brands participate!
In the auto rating oil filter for Volkswagen Passat already 5 brands participate!
In the auto rating brake pads for Mazda 5 already 10 brands participate!
In the auto rating tires for Subaru Outback already 50 brands participate!
For cabin filter Fram already 25 reviews.
Voted AGAINST engine oil RED LINE on the rating page
Voted AGAINST engine oil PENNZOIL on the rating page