The MK2 alternator setup has a fatter bolt than the Mk1 alternator uses. I've seen how the thinner bolt eventually wears into the alternator and it doesn't sit straight. The MK2 alternator setup also scoots the alternator closer to the timing belt end of the engine, giving a little more room by the radiator and a shorter shaft means less torque on the bearings. You'll need the MK2 alternator wiring,.. I just bolt it to the starter.
I have 155k on my 2002 Nissan Frontier XE King Cab 4 cylinder 4x2. No real problems besides a bad alternator and rear e-brake cable that I just replaced
My 93 vw cabriolet is running an oem alternator from the factory.
so far the alternator seams to be working. I cut and then put ends on the red wires and bolted them up. I put my multi meter on one of the two prongs on the clip and grounded the other. then turn the alt motor. the one prong that raised up was my exciter wire.
Also, it seems that it is a 120 amp alternator, so you might want to re-think using the Stock Rabbit harness and, instead, run a bigger cable, since the Rabbit alternators were 60 amps max.
Bought a '91 XE 5 speed in 1996. Sold in 2000. Took it from about 60K to 150K. Pros: Gas Mileage--High 30s, never saw 40 like some people. 5 speed helped keep it peppy. Anvil like reliability. Replaced alternator and clutch.
Alternators don't make good battery chargers and if your alternator is on its way out then it may not be able to charge the battery. A fully charged battery measures 12.6V when the car is not started. When it's discharged by 75% then it measures 12.4V. if it's like 12V then it's totally dead. When you start the engine and the alternator turns, at idle you should have at least 13.4 Volts. If it's less than this then try reving the RPM's to like 2000rpm. You now should have at least 13.4V. If you don't then you have a problem either with the regulator or you have a bad diode.
I have a 99.5 vr6 2.8 afp and missing a alternator ground i think I am getting 20 intermittent ground fault codes and the kid i bought the car from had a alternator put in.
My Rabbit's alternator lasted a solid 40,000 miles!
alright guys...i charged the battery and it started right up...put my meter on the batter with it running and it just kept going down in voltage over a 10 min span...so i would say the alt is bad...
Write your review
Help others - share your experience with this part.
Voted AGAINST engine oil RAVENOL on the rating page
The brake pads NIPPARTS got the first review!
The brake discs Hella got the first review!
The brake discs OEM Suzuki got the first review!
For tires OEM Toyota already 25 reviews.
For tires IRONMAN already 25 reviews.
For starter motor OEM Volkswagen already 25 reviews.
In the rating best ignition coil already 13 brands participate!
In the rating best fuel pump already 5 brands participate!
In the rating best turbocharger already 4 brands participate!
In the auto rating headlights for Volkswagen Golf already 5 brands participate!
In the auto rating brake pads for Mazda 5 already 10 brands participate!
In the auto rating brake pads for BMW M2 already 5 brands participate!
Voted AGAINST engine oil RED LINE on the rating page
Voted AGAINST engine oil PENNZOIL on the rating page
